March 19, 2012 1:32 am
Revised exhaust exits
One of the biggest contentious issues that took place in 2011 was the introduction of blown diffusers. This was a method by which the exhaust gases continued to flow when the engine is on overrun, exiting ahead of the rear diffuser giving additional down force for the corner where there would normally be a minimal amount due to the reduced speed of the car.
The FIA has in its rules for 2012 outlawed the use of blown diffusers and also has placed restrictions on the positioning of the exhaust with the last 100mm being straight and round in section and at an angle to the vertical between 10 and 30 degrees. This is to stop the spaghetti like exhausts of last year as well as some flattening the pipe to affect a wide discharge of the exhaust gases to create the down force over the diffuser. The rule also states that there should be only one exit on either side of the car and that it shall fall between certain points.
It is interesting to see the designs that the different teams have made to minimise the loss of the down force and the results that will be seen in the first race. No matter how many hours of trials and tests in the simulator that the engineers and drivers have, as there is restricted testing on the track, there is nothing like the results from the physical battle of a race.
The general consensus of the teams is to use the bodywork in such a way that the exhaust gases attaches to airflow and sticks to the body creating down force. This is known as the Coanda effect. As the surfaces curve away from the flow of air, low pressure builds, which in turn forces the air to stay attached and in contact with the surfaces, creating the desired down force. Some teams, Red Bull and McLaren have the airflow passing between the wheels and the diffuser whereas others, Ferrari, Lotus and Williams, direct the air towards the centre of the car and over the suspension to boost the rear down force.
In addition to utilising the Coanda effect some teams have also modified their suspension components to be aerodynamically influenced by the airflow from the newly positioned exhausts. This system was utilised by Williams in the 1994 season but was subsequently banned. However, Red Bull has used the rules to best affect requiring no more than 3:5 section profiles of thickness to width. It will be interesting to see who has the best solution and who copies whom.
Rule changes – lower nose
The other major change to the cars in 2012 is the FIA requirement to reduce the height of the nose. This has been put in place primarily to lessen the chance of a car’s nose intruding into the cockpit of another in the event of a side-on collision.
The height immediately ahead of the cockpit remains the same at 625mm above the plain but within 150mm it has to drop to 550mm. This means that several of the cars have used a step making them look a little like duck bills. McLaren seem to be the only manufacturer that has resorted to a smooth transition making their cars look more like the traditional racing car from other classes.
Some of the cars have in their new design introduced ducts ostensibly to cool the driver, as per Red Bull and Sauber but others have chosen to question this as there could be an aerodynamic advantage. Perhaps there will be some challenges in the time to come, particularly if they seem to have a speed advantage. Mercedes has developed frontal intakes whereas Red Bull has it in the step perhaps to disguise the reason that directs air through channels to the front wing to speed up airflow beneath it, this creating an F duct-style down force generator. There have already been challenges made and complaints to the FIA with regards to Mercedes with no outcome at the moment.
Other items
The use of helium in wheel guns has been banned. This is for safety reasons as well as a cost cutting. The result is that the time taken with changing a wheel is slightly longer than previously.
Tyre compounds have been changed by Pirelli to introduce a softer than soft compound in order to make it more difficult for the driver to keep the tyres operating efficiently and not losing grip. Pirelli believes that the result will be more pit stops. Pirelli has also increased the signage and density of the colours on the tyre to allow spectators to identify more easily which compound the driver is using. There had been some confusion with the colour white and colour silver on last year’s tyres.
Drivers will now be only allowed to move once whilst defending their line into a corner and must also allow one car width on the inside of the corner. They also will be able to un-lap themselves whilst under a Safety Car. This allows the leaders to commence racing when the Safety Car goes in without any interference from back markers.
We can look forwards to an interesting season and with the pre-season test results it may be closer than last year with Red Bull running away and everybody trying to catch up.
March 19, 2012 1:34 am
The beginning of a new season is always interesting and in particular for the past three years due to the ban on testing except for specific times, if the cars were not good, like McLaren last year, they are always in catch up mode. The contenders had all redesigned cars due to the major changes in the height to the nose of the car and also the banning of the blown diffuser using exhaust gasses.
With the first practice the new cars showed that there would be strong challenges to the Red Bull supremacy of last year, in particular the McLarens and Mercedes being strong. The first major casualty in Q1 was the 6th world champion in the event, Kimi Raikkonen in his Lotus. He had been caught out on the harder tyres and did not provide a quick enough time to get into Q2 or Q3 and ended in 17th place on the grid. Both the HRT’s were not allowed to start as they were not within 107 per cent of the pole.
The McLarens were supreme in their strategy and took the front row with Hamilton first and Button in second spot. Third place was a surprise with Romain Grosjean in his Lotus which made it even more disappointing for Raikkonen’s mistake with tyres. The other major disappointment was the Ferrari team whose cars did not perform particularly well. Alonso managed only 12th and Massa 16th.
With the rush to the first bend Button in 2nd place managed to outsprint his team mate and pulled away into the lead with Schumacher in his Mercedes in 3rd and Alonso having one of his demon starts and up into 8th place on the first lap. The concertina effect at the first corner caused contact with several cars and Hulkenberg in the Force India retiring. On the next lap Maldonado, who doing well from his 8th place at the start, came into contact with Grosjean finishing his race with broken suspension, a disappointment after such a great qualifying position.
On lap 10 Vettel pushing hard on Schumacher made a mistake on the first bend running wide with Alonso catching. However he managed catch up and the very same bend on the next lap Schumacher had a gearbox problem causing him to go straight on allowing Vettel to pass. Returning to the pits he retired with gearbox problems. One of the other big gains was Raikkonen who was up into 6th place showing all his skills that made him world champion and getting fastest lap up to that point. If only he had started in a better qualifying position we could have had all 6 champions battling with each other.
Pit stops started at the 12 lap stage with the Ferraris but the other main contenders pitted on lap 17. Webber on new rubber produced fastest lap passing back markers. The Caterhams and Marussias were keeping out of the way most of the time but the Saubers, Force Indias and Toro Rossos were mixing it and making things difficult whilst racing each other. Maldonado in the Williams was doing particularly well.
On lap 35 Petrov had a steering problem bringing out the safety car to allow the Caterham to be cleared from the start finish line. The McLarens had pitted for new rubber but Vettel had not but was able to push and then to pit before the safety car was in position and thereby able to gain a place ahead of Hamilton. Button remained in first but had lost his buffer of 10sec. On recommencement he was able to pull away and everybody was jousting for their finishing places.
Unfortunately Massa’s terrible weekend did not improve and he had to retire with accident damage on lap 46 after hitting Bruno Senna. He went wide on a corner and the two cars appeared to be locked together as the Ferrari pushed the Williams off the track. Massa retired and Senna was able to continue for a further six laps before retiring.
The first Grand Prix of the year ended with Button in 1st followed by Vettel and Hamilton. Webber was able to finish a good 4th and Alonso was excellent in 5th as was Raikkonen in 7th after Kobayashi did one of his banzai moves to take 6th. Unfortunately Rosberg had to slow at the end with a loss of tyre pressure and finished 12th after being as high as 6th. Perez and Ricciardo both had outstanding drives for 8th and 9th but di Resta was disappointing in the Force India for the last point place, 10th. The last four were fighting hard crossing the line abreast. Unfortunately Maldonado had an accident on the last lap whilst running in 6th place after a great race.
The season just begun is looking good and we shall see how they fair with the fast circuit in Malaysia next weekend.
November 28, 2011 2:52 pm
The Interlagos Circuit at Sao Paulo, the largest city in the southern hemisphere, is the last race of an eventful season. Practice and qualifying was dry but the forecast for race day was wet, so the teams had a tricky time to get set up right for the race.
Qualifying was quite special with Vettel maintaining his supremacy with his 15th pole of the season and beating the previous record held by Nigel Mansell. Webber was consistent with getting second followed by Button, outperforming his teammate Hamilton. Rosberg did well in 6th place just behind Alonso and outperforming his teammate, Michael Schumacher, yet again.
Revised exhaust exits One of the biggest contentious issues that took place in 2011 was the introduction of blown diffusers. This was a method by which the exhaust gases continued to flow when the engine is on overrun, exiting ahead of the rear diffuser giving additional down force for the corner where there would normally be a minimal amount due
The beginning of a new season is always interesting and in particular for the past three years due to the ban on testing except for specific times, if the cars were not good, like McLaren last year, they are always in catch up mode. The contenders had all redesigned cars due to the major changes in the height to the
The Interlagos Circuit at Sao Paulo, the largest city in the southern hemisphere, is the last race of an eventful season. Practice and qualifying was dry but the forecast for race day was wet, so the teams had a tricky time to get set up right for the race. Qualifying was quite special with Vettel maintaining his supremacy with his
Yas Mariner Circuit is an amazing complex built on a man- made island in the desert state of Abu Dhabi. It is run in the evening under flood lights for prime time TV coverage in Europe and also to avoid the high temperatures during the daytime. Vettel took pole position yet again even though Hamilton beat the time in Q2
The Buddh International Circuit, a brand new track, 30km from Delhi is hot at 31C with lots of dust. Practice was eventful with many offs due to the dust on the track making it very slippery offline with little grip available. There were also penalties of 3 places on the grid given to Perez and Hamilton for ignoring waved yellow
Practice on Friday was wet and very wet so little was done for race setup and Saturday morning, although was not enough time for dry running. Qualifying became very frantic and the two Force India cars of di Resta and Sutil managed to get into Q3 with the Mercedes of Schumacher and the two Testa Rossa cars missing out. The
The track in Suzuka in Japan is liked by a lot of the drivers since being opened in 1969. It is a figure of eight shape with all types of corner to test the drivers. Vettel was able to continue his outstanding performance and snatched pole from Button by 0.009 sec with Hamilton in 3rd after messing up his qualifying
In the heat of the night with start at 9.00pm and temperature at 31c and very high humidity, the drivers have to be very fit to last the almost 2 hours it takes to complete the longest race in the exciting city of Singapore. The front row was taken up by the Red Bull team with Vettel on pole and
Monza is the fastest track of the season with full throttle for 83% of a lap. It is the closest to an oval track with two long straights and two short ones with a couple of chicanes in between. The two Lesmo bends, which are 90 degrees and the Parabolica bend, which is 180 degree constant radius, are all taken
As usual the Spa-Francorchamps circuit produce unpredictable weather with rain during practice and qualifying beginning to dry out. The last runners were the fortunate ones as the track dried out with Vettel beating Hamilton to the pole with Webber, who had been best through practice, in 3rd place. Schumacher had a disaster and did not get a time as his
Recent Comments